Registrations
We now manually approve all new user accounts due to a large influx of spam bots. Accounts are normally approved within 48 hours.
If you need any help with using this Wiki, please ask here: TalkFord.com Wiki Submission Forum
Difference between revisions of "Powerfold Mirrors With Puddle Lights Retro-fit"
Compuwiz uk (Talk | contribs) (New page: == Required Parts == === Facelift === Mirrors with Powerfold & Puddle Lights Powerfold Relay Adjustment Switch With Powerfold Position === Pre-facelift === Same As Above + Both Front ...) |
Compuwiz uk (Talk | contribs) (→Required Parts) |
||
| Line 3: | Line 3: | ||
=== Facelift === | === Facelift === | ||
| − | Mirrors with Powerfold & Puddle Lights | + | Mirrors with Powerfold & Puddle Lights. |
| − | Powerfold Relay | + | |
| − | Adjustment Switch With Powerfold Position | + | Powerfold Relay. |
| + | |||
| + | Adjustment Switch With Powerfold Position. | ||
| + | |||
=== Pre-facelift === | === Pre-facelift === | ||
| Line 12: | Line 15: | ||
Both Front Door Wiring Looms From A Facelift Mondeo. | Both Front Door Wiring Looms From A Facelift Mondeo. | ||
| − | |||
| − | |||
| − | if no brown relay holder is in place then you will need the following too. | + | Interior Front Door Plug From A Scrapped Mondeo for wires & connectors. |
| + | |||
| + | Check Below The Glovebox Fusebox For The Brown Relay Holder. | ||
| + | |||
| + | ''if no brown relay holder is in place then you will need the following too.'' | ||
Brown Relay Holder with wires. | Brown Relay Holder with wires. | ||
| + | |||
Fusebox Plug & wiring. | Fusebox Plug & wiring. | ||
| + | |||
An Additional 5 wires & connectors for the door plug. | An Additional 5 wires & connectors for the door plug. | ||
Revision as of 17:43, 25 September 2008
Contents
Required Parts
Facelift
Mirrors with Powerfold & Puddle Lights.
Powerfold Relay.
Adjustment Switch With Powerfold Position.
Pre-facelift
Same As Above +
Both Front Door Wiring Looms From A Facelift Mondeo.
Interior Front Door Plug From A Scrapped Mondeo for wires & connectors.
Check Below The Glovebox Fusebox For The Brown Relay Holder.
if no brown relay holder is in place then you will need the following too.
Brown Relay Holder with wires.
Fusebox Plug & wiring.
An Additional 5 wires & connectors for the door plug.
Fitting
Facelift
Remove Door Card
Remove Old Mirror Switch From Wiring & Plastic Surround
Refit New Switch To Plastic Cover & Plug Into The Door Loom
Unplug Mirror Wiring
Remove 3 Torx Screws For The Mirror ( remember to support the mirror on the outside when removing the last screw or you get end up with some bad luck )
Fit New Mirror Unit
Refit Door Card
Repeat For Door 2
Remove Glovebox
Insert The Relay
Refit The Glovebox
Pre-Facelift
Remove Door Card
Partially Remove The Foam Weather Seal
Uncouple Door Loom From Car
Uncouple Door Lock Mechanism & Window Motor.
Remove Wiring From The Door
Refit Facelift Door Loom Into The Door
Plug Window Motor & Door Lock Unit Back In
Refit ( Re-seal If Required ) The Inner Weather Seal
Remove Old Mirror Switch From Wiring & Plastic Surround
Fit New Switch To Plastic Cover & Plug Into The Door Loom
Unplug Mirror Wiring
Remove 3 Torx Screws For The Mirror ( remember to support the mirror on the outside when removing the last screw or you get end up with some bad luck )
Fit New Mirror Unit
Refit Door Card
Repeat For Door 2
Remove Glovebox
Insert The Relay
Refit The Glovebox
Add Puddle light Wiring to the interior Of the door Plug in the pin locations found below.
If You Need To Wire In The Powerfold Relay Holder Then You will Need The Following Info
Connector Locations
C54 = Drivers Side Upper Plug C52 = Passenger Side Door Plug C506 = on the rear of the fusebox ( top plug nearest the door on the back )
Powerfold relay pin layout
Pin 1 - C54 Pin 6 & C52 Pin 10 ( Powerfold ) Pin 2 - C54 Pin 10 ( Switch ) Pin 3 - C54 Pin 7 & C52 Pin 1 ( Powerfold ) Pin 4 - C506 Pin 12 ( Power Feed ) Pin 5 - Ground
Puddle Light Wiring
Feeds Taken From The Front Footwell Lights Are easiest
Drivers Side = C54 Pin 12 & Pin 13 Passenger Side = C52 Pin 6 & Pin 7
Submitted By Compuwiz_uk
Your Privacy Choices